94.5-03 FORD POWERSTROKE 7.3 DIESEL TS PERFORMANCE 6 POSITION CHIP 1180401

Description

94.5-03 FORD POWERSTROKE 7.3 DIESEL TS PERFORMANCE 6 POSITION CHIP 1180401
·
FAST SHIPPING - Item(s) in this listing will ship same day if ordered by 3:00 PM (CST) M-F
Description:
The TS Performance 6-
Position
Chip is the most popular and widely used chip hands down for the 7.3L Ford Powerstroke Engine. This chip has been out for the 7.3L Powerstroke Engine for well over 15 years. Tried and proven in the field, tens of thousands of customers find it unbelievable how this single chip can do what is seemingly the impossible; gain more power, while also experiencing better fuel economy. Two things not normally found in the same sentence. For less than 0.00 and appx 15 mins to an hour for installation, you can achieve an average improvement in MPG by 2-4 MPG and up to 140 extra HP. The fuel savings ALONE will pay off the initial investment of buying this chip within the first 3-5k miles driven after installation.
What is included?
·
All TS Performance 6 Position Chips come with the chip
|
switch/controller
|
installation instructions
|
program card
|
Scotch brite scratch pad for cleaning PCM connectors
·
While sales to California residents are allowed, bear in mind this chip is designated by the manufacturer as OFF-ROAD ONLY use in CA
·
This listing is for 1 TS Performance 6 Position Chip Part # 1180401
·
Free phone support provided, see below for details
·
Reprogramming for customers who purchase from us will be significantly discounted vs the + it would cost elsewhere
**IMPORTANT, STOP AND READ**
This listing is for a BLANK CHIP and will need to be programmed in order to work.
We provide programming FREE of charge.
If you want it programmed, include in the payment notes section the
YEAR, MODEL, TRANSMISSION TYPE (AUTO OR MANUAL) AND EMISSIONS TYPE (49 STATE OR CA)
-- (some models and years, we need more vehicle specifics. Read below)
If unable to find notes section, select Contact seller in the listing and send us a message with your vehicle details.
Due to same day processing M-F, failure to provide ALL REQUIRED vehicle details by 3:00 PM (CST) M-F will either result in shipment of a BLANK TS Chip or order cancellation. Buyer will be responsible for shipping chip back for programming.
DETAILS NEEDED for programming:
1.
Vehicle type (F series, Van or Excursion)
2.
Model year (If 1999 model year, provide manufacture date found on inside of driver door jam sticker)
3.
Transmission Type (Manual or Automatic)
4.
ALL F450, F550, E Series/Vans MUST provide PCM box code
5.
Emission type (Federal or California)
6.
Some vehicle applications may not be compatible with this chip, and or, may not have every TS Performance tune option available (we’ll notify         you after purchase for special circumstances). You may also message us with any questions
·
IMPORTANT!: ALL international customers
MUST
pull their PCM and message us with PCM box code, PCM family code, or send a picture of the PCM with one of the stickers in view. International customers who do not supply this info by 3:00 PM CST M-F may be subject to order cancellation.
Alternatively, you can review the below clickable links, then select the link which matches your vehicle application to be directed to another TS Performance listing of ours:
Part # 1180402 | 94.5-97 | Trucks | Auto | Federal Emissions | TDE
Part # 1180403 | 94.5-97 | Trucks | Manual | Federal Emissions | MLE
Part # 1180404 | Early 99, build date 98 | Trucks | Auto| Federal Emissions | XLE
Part # 1180405 | 1999 | Trucks | Manual | Federal Emissions | AWA
Part # 1180406 | 99.5-01 | Trucks | Auto | Federal Emissions | NVK
Part # 1180407 | 2000 | Trucks | Manual | Federal Emissions | DAC
Part # 1180408 | 2001 | Trucks | Manual | Federal Emissions | APX
Part # 1180409 | 2002-2003 | Trucks | Auto | Federal Emissions | VDH
Part # 1180410 | 2002-2003 | Trucks | Manual | Federal Emissions | AEB
Part # 1180411 | 00-01 | Trucks And Excursion | Auto | California Emissions | UKN0
Part # 1180412 | 02-03 | Trucks And Excursion | Auto | California Emissions | QLJ
Part # 1180413 | 94.5-97 | Trucks | Manual | California Emissions | JKA
Part # 1180414 | 94.5-97 | Trucks | Auto | California Emissions | MME
Part # 1180415 | 98-99 | Vans | Federal Emissions | MLU
Part # 1180416 | 1999 | Trucks | Manual | California Emissions | ZDR
Part # 1180417 | 1999 | Vans | California Emissions | VCQ
Part # 1180418 | 1999-2002 | Vans | California Emissions | SZT
Part # 1180419 | 00-01 | Trucks | Auto | California Emissions | IQW
NOTE: Unless customer specifies differently, when we program chips, they are programmed with the following:
·
Stock
·
High Idle
·
50 HP
·
75 HP
·
100 HP
·
140 HP Extreme
If you prefer different programming, please include 6 of the following 8 available tunes. Please be sure to put them in the order you want.
1.
Stock
2.
High Idle
3.
50 HP
4.
75 HP
5.
100 HP
6.
140 HP Extreme
7.
Anti-Theft (Engine will NOT start in this position)
8.
Valet (Speed limiter, will not go beyond 70 MPH. Great for fleets, parents, etc)
INSTALLATION TIPS:
·
Please make sure to follow all installation instructions. There are plenty of how-to-videos available online.
Proper Battery disconnection process:
·
When disconnecting the batteries, disconnect
both
positive and negative from both batteries.
After both batteries have been disconnected, touch opposing positive and negative cables together to
DISCHARGE
the remaining electricity within the system; not to worry, the voltage is low enough, this won’t be dangerous if you followed our instructions
Alternatively
, you can simply disconnect both batteries, then cycle the key in the ignition (attempting to start it 2-3 times) and on one of the cycles, leave key in the “ON” position, then attempt to turn on the radio and run the air. This procedure is considered the safest method to discharge the remaining electrical charge in the system.
FAILURE to discharge the remaining electrical charge in the system may result in frying your PCM Box
J-Port aka PCM Port cleaning process:
·
Gently
scrape bulk of protective coating from
BOTH
sides of the J-Port (where TS Chip will install on PCM) using a flat tip screwdriver (do
NOT
use a knife)
·
Take the included abrasive pad and wrap around tip of a flat tip screwdriver
·
With the abrasive pad wrapped around the screwdriver, scrub vigorously for 3-5 seconds and inspect, repeat this step until copper has been exposed on all “fingers”
Mini tip: Use a flashlight to aid in the inspection process
·
Note: For those “stubborn fingers”, try to focus on those areas once bulk of “fingers” have copper exposed
·
If the “fingers” do not have copper exposed on at least the last ¼ inch of each “finger” on BOTH sides, you will run into no start issues, intermittent vehicle operation, etc…
PHONE SUPPORT AVAILABLE FOR FREE!
Please send us an eBay message requesting phone installation support and we will promptly call you.
We can provide helpful tips to prep for the install, or even walk you step-by-step through the install.
We are available between 9:00am-6:00pm (CST) M-F for installation support. Text or call with at least a 24 hour notice if your install will take place outside our standard hours of operation.
Disclaimer: Buyer assumes all liability and holds us, the seller, harmless from any and all liabilities or damages which may occur as a direct or indirect result of proper or improper installation and use of any aftermarket product purchased from us.
We always recommend having a professional install any performance upgrades. By installing any performance product yourself, you assume ALL risks and liabilities and any losses/damages that may occur. If you are in doubt, please consult a professional. Buyer is and assumes all responsibility for adhering to any and all local laws surrounding the use of this or any aftermarket product purchased from us when driving the vehicle on public roadways.
Item condition:
Brand new, never used in factory packaging
Contents within (as pictured) are all brand new and never used, nothing is missing
Packaging:
We take great care in packing every item we ship.
Buy with confidence knowing your item(s) ordered from us are guaranteed to arrive "safe n sound"
Shipping:
All items in this listing are guaranteed to ship same day if ordered by 3:00PM CST M-F
We always use the fastest, most economical shipping method for item(s) with free shipping
If one option costs us an extra dollar, but will be to you 2 days earlier, we spend the extra dollar
If you need expedited shipping and no option is provided in the listing, please select “Contact Seller” and send us a message with your request and zip code for a quote
Returns:
·
To qualify for
FREE RETURNS
, please make sure to return the item(s) in the
exact condition
they were received, this includes taking extra care in repacking to avoid damage during transit back to us.
Returns must first be authorized by us and be accompanied with a RMA # which we will provide
All returns are subject to a restocking fee and deduction of shipping costs to help us recoup losses during returns
Restocking charges will typically start at the minimum of 5% and top out at 35%, depending on condition of return, a return be rejected, and or, charged full amount eBay allows us to which is currently 50%
To avoid maximum restocking and shipping charges allowed per eBay policy, simply return item(s) in the exact condition they are received
If we believe an item has been damaged due to installation negligence, your return will be rejected and the item(s) returned to you
Open-box and clearance items are non-returnable and treated as “all sales final” unless specified otherwise
All  items with factory seals, have a one-time use, and or lock to one application/vehicle/motorcycle are
not
returnable once opened
For these items, we will require a photo showing whether or not seal has been broken. Photos must be sent within eBay messaging.
Should we approve a return on one time use/VIN locked, and or, broken factory sealed items; a restocking fee of 50% will be charged, in addition an unlock fee starting at 0 (where applicable), plus both-ways shipping costs will be deducted after the restocking fee
If we approve return on an item where the factory seal was broken/removed, a restocking fee of 50% along with shipping charges will be deducted from your refund
The above applies primarily, but is not limited to the following: Performance chips, tuners, electronic performance devices, etc
Note: The restocking fee is a tool we use to mitigate and eliminate losses that occur when buyers return item(s). Charging restocking and shipping costs on returns, regardless of condition, help allow us to remain competitive and keep our prices low. Please do your due diligence in researching the item prior to purchase; this includes checking reviews, forums, speaking with the manufacturer and yes, even contacting us with any questions prior to your purchase.